Ten Ways to Extend the Service Life of Electric Vehicle Lithium Batteries

How to extend the service life of lithium batteries for electric vehicles? The times are advancing, and everyone advocates energy-saving, environmentally friendly, and environmentally friendly electric bicycles and electric vehicles into thousands of households. So, how to ensure that the battery does not run out so quickly? The following is the use of electric vehicle batteries. 1. If the electric vehicle charger is normal and the driving is less than 10km per day, the brand new battery can be refilled with deionized water after the warranty period ends. For electric vehicles that drive 50km a day, check the battery condition after 8 months, and properly replenish deionized water, 3~4ml per cell, especially in summer. Remember to close the safety valve after adding water. I think that one person’s electric car is often taken, and it is recommended to check it in about half a year and maintain it according to the usage. 2. Many electric vehicle users have found that due to the difference in the distributed capacitance between the battery and the vehicle body, the positive electrode of the battery tends to lag behind, so that the battery suffers the most damage. At the same time, place the batteries in the middle and the next position in the water, so that the batteries sit upright in sequence. 3. Do not charge when the power is above 80%, but you can charge when there is a chance to charge 30%-80%, and you must charge when it is less than 30%. 4. The acceleration should be gentle and not overloaded. Use the foot pedal device to help you move as much as possible at the beginning and uphill. 5. The battery in the battery box should be sealed with paper. If possible, use double-sided foam glue on the bottom to prevent battery vibration. 6. Complete discharge once a month, and then continue to charge for 12h. 7. When replacing the battery, be sure to check the charger parameters to keep the battery and charger matching. 8. If it is difficult for the charger to turn green or turn green as soon as it is charged, or the battery temperature rises abnormally during the charging process, please check whether it is the charger or the battery immediately. 9. Regarding ordinary chargers without temperature compensation, in summer, the charger and the battery use 6A10 diodes in series, and the gel battery is used in series with two 6A10 diodes; the diode is short in the rest of the time. 10. Keep the vehicle in good mechanical and technical condition, adequate tire pressure, good lubrication, and normal brake clearance and tightness. Achieve the above 10 measures, lithium batteries can double the service life. Disclaimer: Some pictures and content of articles published on this site are from the Internet. If there is any infringement, please contact to delete. Previous: Classification and structure of lithium batteries